Mitsubishi MU-2

MU-2
Mitsubishi MU-2B-25 of Air Prague
Role Utility transport aircraft
National origin Japan
Manufacturer Mitsubishi
First flight 14 September 1963
Produced 1963-1986
Number built 704[1]


The Mitsubishi MU-2 is one of postwar Japan's most successful aircraft. It is a high-wing, twin-engine turboprop, and has a pressurized cabin.

Design and development

MU-2 landing

Work on the MU-2, Mitsubishi's first postwar aircraft design, began in 1956. Designed as a light twin turboprop transport suitable for a variety of civil and military roles, the MU-2 first flew on 14 September 1963. This first MU-2, and the three MU-2As built, were powered by the Turbomeca Astazou turboprop.[2]

Civil MU-2s powered by Garrett engines were certified as variants of the MU-2B, using the MU-2B type followed by a number. For marketing purposes, each variant was given a suffix letter; the MU-2B-10, for example, was sold as the MU-2D, while the MU-2B-36A was marketed as the MU-2N.[3]

Production

In 1963 Mitsubishi granted Mooney Aircraft rights in North America to assemble, sell and support the MU-2. In 1965, Mooney established a facility to assemble MU-2s at its new factory in San Angelo, Texas, major components were shipped from Japan and the San Angelo factory installed engines, avionics and interiors, they would then paint, flight test and deliver to customers. By 1969 Mooney was in financial difficulty and the San Angelo facility was taken over by Mitsubishi. Production in the United States ended in 1986 with over 750 MU-2 aircraft sold.[4] The last Japanese-built aircraft was completed in January 1987.

The subsequent production aircraft, designated MU-2B, were delivered with the Garrett TPE331 engines that remained standard on all later models. Thirty-four MU-2Bs were built, followed by 18 examples of the similar MU-2D.[2] The Japanese armed forces purchased four unpressurized MU-2Cs and 16 search and rescue variants designated MU-2E. Featuring slightly more powerful upgraded TPE331 engines, 95 examples of the MU-2F were sold.

A stretched-fuselage Mitsubishi MU-2 Marquise taxiing at the Toronto City Centre Airport. This MU-2 is operated in a medivac configuration by Thunder Airlines of Thunder Bay, Canada

The fuselage was stretched beginning with the MU-2G. The MU-2M (only 28 built) is regarded as the toughest and most desired of all short body MU-2s, especially with a -10 engine conversion. It had a short fuselage and the same engines as the MU-2K and stretched MU-2J and had an increase in cabin pressurization to 6.0 psi; it was followed by the MU-2P, which had newer four-blade propellers. The final short-fuselage MU-2s produced were known as the Solitaire and were fitted with 496 kW (665 shp) Garret TPE331-10-501M engines.[2]

The first significant change to the airframe came with the stretched MU-2G, first flying 10 January 1969, which featured a 1.91 m (6 ft 3 in) longer fuselage than earlier models; 46 were built before being succeeded by the more powerful MU-2J (108 constructed). The MU-2L (29 built) was a higher-gross-weight variant, followed by the MU-2N (39 built) with uprated engines and four-blade propellers. The final stretched-fuselage MU-2 was named the Marquise, and like the Solitaire used 533 kW (715 shp) TPE331 engines.[2]

As of 2005, 397 MU-2 aircraft are registered in the United States.

Operational history

Military service

A military version for JGSDF.

The Japanese Self-Defense Forces are the only military operators to have flown the MU-2 in front-line service. The four C-model aircraft built, in addition to 16 MU-2Ks, entered service with the Japan Ground Self-Defense Force with the designation LR-1; they were used as liaison and photo reconnaissance aircraft. 29 MU-2Es were purchased by the Japan Air Self-Defense Force as search-and-rescue aircraft and designated MU-2S. Additional equipment consisted of a "thimble" nose radome, increased fuel capacity, bulged observation windows, and a sliding door for dropping rafts.[3]

MU-2s are currently flown under government contract at Tyndall Air Force Base, Florida, where they provide U.S. Air Force undergraduate Air Battle Manager students with their initial experience controlling live aircraft. Students must control eight MU-2 missions before they can progress to controlling high performance aircraft such as F-15s or F-22s.[5]

The Royal New Zealand Air Force announced 29 July 2009 that it will take delivery of four non-flying Mitsubishi MU-2F fixed-wing training aircraft during third quarter 2009 for use as training aids. The aircraft will be located at the RNZAF's Ground Training Wing (GTW) at Woodbourne near Blenheim. [6]

Flight around the world

On August 25, 2013 Mike Laver, owner and pilot of N50ET (a -10 engine converted 1974 K model equipped with 5 blade MT composite propellers which had just received an STC under Air 1st of Aiken SC) along with AOPA Pilot technical editor Mike Collins embarked on an around the world journey in the MU-2B-25.[7] The voyage commenced at Aiken Municipal Airport and sojourned in Nagoya, Japan on September 14, 2013; the 50th anniversary of the MU-2.[8][9][10]

Safety concerns

Concerns have been raised about safety; there have been 337 fatalities from MU-2 crashes.[11] As of October 2005, the Federal Aviation Administration (FAA) has begun a safety evaluation of the aircraft and decided that the aircraft has met its certification requirements - it is safe when operated by properly trained pilots who operate properly maintained aircraft. The FAA is in the process of mandating training specific to the MU-2 as it has in the past for other aircraft. When such mandated training was required outside of the U.S. the MU-2 accident record was vastly improved.

Because the MU-2 offers very high performance at a relatively low cost, some of its operators lack sufficient training and experience for such an advanced aircraft. The MU-2 has performance similar to a small jet, yet early pilot licensing required only a simple endorsement from much slower twin piston-engined licenses. The large number of MU-2 pilots who were inexperienced at high speeds and high altitudes seems to be the cause of the high crash rate. Once a type certification was required for an MU-2 license the accident rate dropped to normal levels.

A design feature of the MU-2 is its high cruise speed while having a low landing speed. This is accomplished by using full-span, double-slotted flaps on the trailing edge of the wing. These flaps give the MU-2 a wing area comparable to a Beech King Air in landing configuration while having a wing area comparable to a light jet while in cruise mode. The full-span flaps meant that over-wing spoilers were employed instead of conventional ailerons. These spoilers are highly effective, even when the MU-2 wing is stalled. Some fatal accidents have occurred because normal engine-out procedures for light twin aircraft are not effective when flying the MU-2. The commonly taught procedure of reducing flap following an engine failure on take off leads to a critical reduction in lift in the MU-2 due to the highly effective double-slotted flaps. When pilots were taught to retain take-off flap and to reduce climb rate in the event of an engine failure, MU-2 accident rates were reduced to almost nil.

From an FAA press release:

The FAA began an aggressive safety evaluation in July 2005. The evaluation is performing a detailed review of accidents, incidents, airworthiness directives, service difficulty reports, safety recommendations and safety reports. It also is examining pilot training requirements, the history of the aircraft's commercial operators and possible engine problems. The goal is to identify the root causes of MU-2 accidents and incidents and determine what, if any, additional safety actions are needed.

In early 2008, the FAA issued a Special Federal Air Regulation (SFAR) directed at MU-2B operations. Pilots flying this aircraft after that date (current MU-2 pilots would have a year to come into compliance) were required to receive type-specific initial training, as well as recurrent training. It also required that a fully functional autopilot be available for single-pilot operations, and that FAA-approved checklists and operating manuals be on board at all times. Also unusual for this SFAR, pilot experience in other aircraft types cannot be used to comply with MU-2 operational requirements - for instance, the requirement to perform landings within the preceding 90 calendar days before carrying passengers is altered by this SFAR to require those landings be made in the MU-2.[12]

As of March 29, 2016 there have been 3 fatal accidents involving the MU-2 since the FAA SFAR (Title 14; Part 91, SFAR Number 108) was implemented.

Variants

Short fuselage

XMU-2
Astazou-powered prototype, one built
MU-2A
Astazou-powered development aircraft, three built.
MU-2B
Production variant with Garrett TPE-331 engines, 34 built.
MU-2C (MU-2B-10)
Unpressurised variant for the Japanese Ground Self Defense Force, four built.
MU-2D (MU-2B-10)
Improved MU-2B, higher operating altitude and bladder fuel tanks rather than wet-wings, 18 built.
MU-2DP (MU-2B-15)
MU-2D with 90-gallon tip tanks and upgraded engines, three built.
MU-2E
Unpressuised variant for the Japanese military designated MU-2S
MU-2F (MU-2B-10)
Variant with improved engines and 90-gallon tip tanks as MU-2DP but certified at a higher gross weight and additional fuel tanks, 95 built.
MU-2K (MU-2B-25)
Short fuselage variant of the MU-2J, 83 built.
MU-2M (MU-2B-26)
Revised variant of the MU-2K with increased weight, and increased cabin pressure, 27 built.
MU-2P (MU-2B-26A)
Improved variant with four-bladed propellers and improvements as MU-2N, 31 built.
Solitaire (MU-2B-40)
Variant with improved engines and increased fuel capacity, 57 built between 1979 and 1985.

Long fuselage

MU-2G (MU-2B-30)
Stretched variant with a 1.91m increase in length, larger cabin and change to landing gear configuration, first flown in January 1969, 46 built.
MU-2J (MU-2B-35)
Variant with improved engines, eleven inch increase in cabin length and increased gross weight, 108 built.
MU-2L (MU-2B-36)
Revised variant of the MU-2L with increased weight, and increased cabin pressure.
MU-2N (MU-2B-36A)
Improved variant with four-bladed propellers and other improvements including an extra cabin window, 36 built.
Marquise (MU-2B-60)
Variant with improved engines, 139 built.
Cavenaugh Cargoliner
Freighter conversions of long fuselage MU-2 variants by Cavenaugh Aviation Inc. of Conroe, Texas, by addition of a crew door in place of a flight deck window and a large cargo door in the rear port fuselage. Eleven aircraft had been converted by March 1987.[13]

Military

LR-1
Japanese military designation for MU-2C and MU-2Ks operated by the JGSDF, 20 delivered.
MU-2S
Japanese military designation for a MU-2E search and rescue variant for the air force, 29 delivered.

Aircraft on display

This aircraft had been used on coastal surveillance duties under controversial circumstances over the appointment of the contracting company. The plane was sold to a parts recycler who removed hi value parts such as the engines and the airframe was handed to the museum for static display.

Incidents and accidents

  • On 24 May 1983, VH-MLU, an MU-2B-60 crashed near Bargo, New South Wales. The pilot, the sole occupant, was killed.
  • On 26 January 1990, an MU-2B-60 crashed near Meekatharra, Western Australia. The pilot and one passenger were killed. The Leonora investigation was extended to include this crash given the same aircraft type crashed in similar circumstances.[17]
  • On 21 December 1994, an MU-2B-30 crashed in similar circumstances on approach to Melbourne Airport. The pilot was killed.[19][20]

Specifications (MU-2L)

Data from Jane's All The World's Aircraft 1976-77[29]

General characteristics

Performance

See also

Aircraft of comparable role, configuration and era

References

  1. ↑ "The Mitsubishi MU-2 Story". AvBuyer. Retrieved 2 September 2013.
  2. 1 2 3 4 Mondey, David; et al. (1981). "Mitsubishi MU-2/Marquise/Solitaire Series". The Encyclopedia of the World's Commercial & Private Aircraft. Crescent Books. p. 203. ISBN 0-517-36285-6.
  3. 1 2 "Mitsubishi MU-2". Airliners.net. Retrieved 2006-03-07.
  4. ↑ Sparaco, Pierre (2006-08-14). "Ready for Prime Time?". Aviation Week & Space Technology magazine. p. 45.
  5. ↑ MU-2 pilots provide valuable ABM training
  6. ↑ http://www.defense-aerospace.com/cgi-bin/client/modele.pl?shop=dae&modele=release&prod=107102&cat=3
  7. ↑ http://blog.aopa.org/blog/?page_id=5288
  8. ↑ Mike Laver travels the world in 25 days
  9. ↑ The flight was completed in 101.5 hours(27,475 nautical miles)and was incredibly flown without a single squawk or maintenance issue whatsoever. name=http://blog.aopa.org/blog/?page_id=5288/
  10. ↑ https://share.delorme.com/MikeCollins/
  11. ↑ "Archives - February 2007 (Premiere Show)". Business Nation. CNBC.com. Retrieved 2007-05-01.
  12. ↑ FAA Issues New Pilot Qualifications for MU-2, Flying Magazine, Vol. 135., No. 5, May 2008, p. 22
  13. ↑ John W.R. Taylor, ed. (1988). Jane's All the World's Aircraft 1988-89. London: Jane's Information Group. p. 373. ISBN 0 7106 0867 5.
  14. ↑ http://www.darwinsairwar.com.au/mitsubishi-mu/
  15. ↑ http://www.airliners.net/photo/Japan---Army/Mitsubishi-LR-1-%28MU-2C%29/1481367/
  16. ↑ "NTSB Report DCA83AA022"
  17. 1 2 "MU-2, VH-BBA, Leonora WA, 16 December 1988 and MU-2, VH-MUA, Meekatharra WA, 26 January 1990". Australian Transport Safety Bureau.
  18. ↑ "ASN Wikibase Occurrence # 137039".
  19. ↑ "ASN Wikibase Occurrence # 137041".
  20. ↑ "ASN Wikibase Occurrence # 28401".
  21. ↑ Governor George S. Mickelson. Years in Office: 1987-1993
  22. ↑ NNDB Soylent Communications
  23. ↑ Associated Press, "Wife: Pilot husband among 3 killed in Ohio crash", 18 January 2010 (accessed 25 January 2010)
  24. ↑ Fox 8, "NTSB: No Signs of Trouble in Fatal Plane Crash", Fox 8 News (accessed 25 January 2010)
  25. ↑ "Obituary for Don Brown, Avon, OH"
  26. ↑ News on 6
  27. ↑ Family Files Lawsuit Over Owasso Plane Crash That Killed Perry Inhofe
  28. ↑ "Small passenger plane crashes on Quebec's Magdalen Islands"
  29. ↑ Taylor 1976, pp. 127-129.

External links

Wikimedia Commons has media related to Mitsubishi MU-2.
This article is issued from Wikipedia - version of the Thursday, May 05, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.