Perstraction

Perstraction is a typical perstraction includes two liquid phases but only other phase includes an extractant. Perstraction can be more gentle, faster and cheaper than the traditional biphase extraction. There many potential applications. Perstraction has been applied to oil refining, decontamination of drinking water and improving the downstream process in biorefineries (source?).

Perstraction is about 30-year-old technique. It is analogous to pervaporation. The technique is used commercially (source?). There are many good ideas and potential applications but they have met problems. Membranes can not be done in the cheap way. Usually many compounds can not be extracted concurrently.

Introduction

Perstraction is the separation technique which has been developed from biphase extraction. Phases are separated by a membrane in perstaction.[1] Organic and aqueous phases do not mix in each other. A basic perstraction is called the single perstraction or membrane perstraction. An advantage is minimizing toxic damage to microorganisms or enzymes. Nevertheless perstraction includes problems like expensive membranes, clogging and fouling of membranes.[1]

Membrane perstraction is not only perstraction technique (Figure 2). Capsular perstraction is fast saving energy and solvents.[2] Unfortunately capsules ca not be produced large amounts in the cheap way and the alginate capsule is labile mechanically. Enzymes can be immobilized to the capsule membrane.[3]

Applications

Perstraction in butanol fermentation

Perstraction is used in the butanol fermentation.[4] Toxic butanol is a problem in high initial sugar concentrations. The research of product removal started in the end of the 1980s. Butanol has been tried to remove during fermentation by many techniques like adsorption, gas stripping and liquid–liquid extraction. The latter has been reported to be one of the economical techniques. Nevertheless it includes problems. Extractants can be toxic to cells, they can accumulate to wrong places like cells, loss of them phase separation may be bad etc.

A solution is perstraction to these problems. A butanol permeable membrane is placed in between the fermentation broth and extractant solvents.[4] Fermentation products diffuse through the membrane by the vapour pressure difference. The technique enhances cell growth, improves productivity and recovers butanol economically. Nevertheless, it should be developed. Butanol diffuses through the connecting tube which means loss of product. Secondly the butanol flux could be higher through a membrane.

Amino acids separation through the charged membrane

A membrane brings many new elements for the separation. Amino acids has been separated by perstraction.[3][5] Membranes did not only separate extractants and the primary solution but also were selective for amino acids. Charged membranes were used. So they selected amino acids by pKa. Besides the selectivity of a membrane is affected by its thickness, pore diameter and charge potential. The bigger pore is, the better amino acids permeate the membrane. The higher charge potential is, the bigger electrostatic rejection effects are. The thinner membrane, the less it is selective.

The clean groundwater

Pollutants can be deleted from groundwater by perstraction.[6] Different techniques have been patented.[7] The oldest one has published in 1990 and the youngest one in 1998. In the 2000s has been done few patent applications but no granted patents.[8]

Organic compounds through a membrane has been concentrated from groundwater.[6] The concentration factor is from 1 000 to 10 000 bringing 0.1 ppb concentrations to between 0.1 and 1.0 ppm. Besides the concentration of a contaminant has been analyzed in real-time. The membrane is polymer like polysulphane. The hole diameter is 300 µm and thickness is 30 µm.

Removal of pharmaceuticals from water

The pharmaceuticals pass sewage treatment plants. They like estrogen conjugates may cause problems. Drugs of the research were common, present in the aquatic environment and inability to be adequately removed by sewage treatment plants.[9] There were seven different drugs in the research. Dibutyl sebacate and oleic acid formed liquid cores in capsules because they do not diffuse away from capsules and have affinity for drugs. Capsule external diameters were 740 µm and 680 µm and internal diameters were 570 µm and 500 µm. Agitation was 300 rpm. Equilibrium times were 30, 50 and 90 minutes.

Since dibutyl sebacate and oleic acid were different affinity for drugs, they were used concurrently.[9] Four drugs were extracted effectively for 40–50 minutes (at least 50% removed). Extraction rates did not change significantly above 150 rpm. Membrane thickness did not affected significantly. On the contrary the capsule size was remarkable for mass transfer.

Hydrophobic gelganamycin separated from aqueous media

An antibiotic called geldanamycin was separated from media by the capsular perstraction.[2] Geldanamycin is hydrophobic. Outer particle diameter varied from than less 500 to 750 µm. Alginate formed the shell of capsule and its thickness varied from 30 to 90 µm. Dibutyl sebacate or oleic acid as liquid core extracted geldanamycin well. The bigger agitation and thinner capsule membrane were, the faster transfer rate was.

Geldanamycin was back-extracted from capsules.[2] Dibutyl sebacate capsules were disposable because liquid core came out from capsules in the back-extraction. On the contrary oleic acid remained in capsules during the back-extraction when an extractant was saturated with oleic acid. Nevertheless the presence of oleic acid in the back-extraction solution demanded more purification steps (precipitation, centrifugation and filtration). Oleic acid was removed because it prevents crystallization of geldanamycin. Therefore geldanamycin was crystallized and the end product was highly purified.

Enzymes can be immobilized to the capsule membrane.[3] In this case the capsule external diameter was 500 µm and internal diameter 300 µm. The product of enzyme-catalyzed reaction can be concentrated to capsules and the end-product inhibition is low.[10] Enzyme recycling could be performed by back-extracting the product. The technique has been applied to the hydrolysis of penicillin G.

References

  1. 1 2 LUQUE, R., CAMPELO, J. and CLARK, J., eds, 2011. Handbook of Biofuels Production – Processes and Technologies. Woodhead Publishing.
  2. 1 2 3 WHELEHAN, M. and MARISON, I.W., 2011. Capsular perstraction as a novel methodology for the recovery and purification of geldanamycin. Biotechnology progress, 27(4), pp. 1068–1077.
  3. 1 2 3 WYSS, A., VON STOCKAR, U. and MARISON, I.W., 2006. A novel reactive perstraction system based on liquid-core microcapsules applied to lipase-catalyzed biotransformations. Biotechnology and bioengineering, 93(1), pp. 28–39.
  4. 1 2 QURESHI, N. and MADDOX, I.S., 2005. Reduction in Butanol Inhibition by Perstraction: Utilization of Concentrated Lactose/Whey Permeate by Clostridium acetobutylicum to Enhance Butanol Fermentation Economics. Food and Bioproducts Processing, 83(1), pp. 43–52.
  5. ↑ ISONO, Y., FUKUSHIMA, K., KAWAKATSU, T. and NAKAJIMA, M., 1995. New selective perstraction system with charged membrane. Journal of Membrane Science, 105(3), pp. 293–297.
  6. 1 2 ANONYMOUS, 1997. Groundwater monitor uses perstraction. Membrane Technology, 1997(90), pp. 3–4.
  7. ↑ ANONYMOUS A, 2012, United states patent. Available: http://patft.uspto.gov/ [1/6/2012]
  8. ↑ ANONYMOUS B, 2012, Patent Lens home. Available: http://www.patentlens.net/daisy/patentlens/patentlens.html [10/6/2012]
  9. 1 2 WHELEHAN, M., VON STOCKAR, U. and MARISON, I.W., 2010. Removal of pharmaceuticals from water: Using liquid-core microcapsules as a novel approach. Water research, 44(7), pp. 2314–2324.
  10. ↑ WYSS, A., SEITERT, H., VON STOCKAR, U. and MARISON, I.W., 2005. Novel reactive perstraction system applied to the hydrolysis of penicillin G. Biotechnology and bioengineering, 91(2), pp. 227–236.
This article is issued from Wikipedia - version of the Tuesday, November 18, 2014. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.