Toyota TS030 Hybrid

Toyota TS030 Hybrid

Anthony Davidson in the TS030 at the 2013 24 Hours of Le Mans
Category	LMP1
Constructor	Toyota Motorsport GmbH
Successor	Toyota TS040 Hybrid
Technical specifications
Chassis	Carbon fibre and aluminium honeycomb monocoque
Suspension (front)	Independent double wishbone pushrod system
Suspension (rear)	Independent double wishbone pushrod system
Width	2,000 mm (78.7 in)
Height	1,030 mm (40.6 in)
Engine	Toyota 3.4 L (3,400 cc) 90-degree V8 Normally aspirated mid, longitudinally mounted
Transmission	6-speed sequential manual Viscous mechanical locking differential
Fuel	Total petrol
Competition history
Notable entrants	Toyota Racing
Notable drivers	Sébastien Buemi[1] Anthony Davidson[1] Kazuki Nakajima[2] Nicolas Lapierre[2] Alexander Wurz[2] Stéphane Sarrazin
Debut	2012 24 Hours of Le Mans
Races Wins Poles F.Laps 14 5 6 4
Constructors' Championships	0
Drivers' Championships	0

The Toyota TS030 Hybrid^[3][4] is a motor racing car developed under Le Mans Prototype rules. The car ran at the 2012 24 Hours of Le Mans, with two cars being entered in the LMP1 category,^[5] and became the first petrol-powered hybrid car to be entered in the FIA World Endurance Championship.^[6]

The car features the Kinetic Energy Recovery System (KERS) regenerative braking device (the Le Mans organisers, ACO, use the alternate name ERS) to charge a supercapacitor. The extra power is directed to the rear wheels. Under the 2012 Le Mans rules they were allowed to use the system at any speed, unlike Audi who had elected to send power to the front, with a restriction to a minimum speed of 120 km/h.^[7]

Racing History

2012

The car marked Toyota's first works entry at the 24 Hours of Le Mans since the Toyota GT-One was entered in the 1999 race. The car was expected to make its debut at the 6 Heures de Spa-Francorchamps in May 2012,^[8] but a testing crash at Paul Ricard damaged the chassis beyond repair, and the team was forced to delay the TS030's debut until the 24 Hours of Le Mans in June because of the time needed to produce a new monocoque.^[9] On lap 82 at Le Mans, Anthony Davidson's TS030 became airborne after a collision with Piergiuseppe Perazzini's Ferrari, and collided hard with track barriers. Davidson suffered two broken vertebrae (T11 & T12) from the incident.^[10] The second TS030, which had briefly led the race before the accident, retired several hours later after an engine failure.

After finishing in second place at the 6 Hours of Silverstone, the TS030 Hybrid took its first pole position and victory at the 6 Hours of São Paulo race, held at the Autódromo José Carlos Pace in São Paulo, Brazil.^[11] It finished the 2012 season with two more victories at the 6 Hours of Fuji and the 6 Hours of Shanghai.

2013

With the new schedule for 2013, the first race of the year, 6 Hours of Silverstone saw Toyota enter with two 2012 spec TS030's. Both Toyota's showed stunning pace in qualifying, with the #7 machine qualifying more than 3 seconds ahead of the nearest Audi, whilst the #8 sister car qualified second. The race however was at best uneventful, with neither car being able to match either Audi's pace, finishing third and fourth overall having struggled in the first few hours of the race with tyre management. The second round at Spa-Francorchamps would see Toyota debut the new 2013 specification TS030 featuring a revised aerodynamic package and including an updated monocoque.^[12] After a close qualifying session, the updated #7 ran near the front of the race for the first three hours, before retiring due to overheating brakes as a result of a malfunctioning energy recovery system. With the rear brake assembly designed to be assisted with certain amounts of mechanical retardation provided by the hybrid recovery system by design, it did not provide the deceleration when malfunctioning, thus overloading the conventional rear brakes. The sister car remained in fourth for the rest of the event, closing what was a mixed outcome for the team.^[13] Post race, technical director Pascal Vasselon 'explained that his team's analysis from Spa showed that the current Balance of Performance significantly favours Audi's turbodiesel powerplant over its own normally-aspirated petrol engine', calling for the ACO and FIA for more favourable balance of performance to be applied before Le Mans.^[14]

As agreed at the start of the season, the FIA and the ACO reviewed the technical regulations at the end of May 2013 to adjust the performance between petrol and diesel LMP1 cars for the remainder of the 2013 WEC Championship. From the 24 Hours of Le Mans onwards, petrol-engined cars will have an additional 3 litres of fuel capacity.^[15]

Results summary

Results in bold indicate pole position. Results in italics indicate fastest lap.

Year	Entrant	No.	1	2	3	4	5	6	7	8	Points	WEC
2012			SEB	SPA	LMS	SIL	SÃO	BHR	FUJ	SHA	96	2nd
	Toyota Racing	7			Ret	2	1	Ret	1	1
		8			Ret

Year	Entrant	No.	1	2	3	4	5	6	7	8	Points	WEC
2013			SIL	SPA	LMS	SÃO	COA	FUJ	SHA	BHR	142,5	2nd
	Toyota Racing	7	4	Ret	4			1	2	Ret
		8	3	4	2	Ret	2	27	Ret	1

Victories

No.	Event	Circuit	Location	Season	Drivers
1	6 Hours of São Paulo	Autódromo José Carlos Pace	São Paulo, Brazil	2012	Alexander Wurz Nicolas Lapierre
2	6 Hours of Fuji	Fuji Speedway	Oyama, Japan	2012	Alexander Wurz Nicolas Lapierre Kazuki Nakajima
3	6 Hours of Shanghai	Shanghai International Circuit	Shanghai, China	2012	Alexander Wurz Nicolas Lapierre
4	6 Hours of Fuji	Fuji Speedway	Oyama, Japan	2013	Alexander Wurz Nicolas Lapierre Kazuki Nakajima
5	6 Hours of Bahrain	Bahrain International Circuit	Sakhir, Bahrain	2013	Anthony Davidson Stéphane Sarrazin Sébastien Buemi

See also

• TMG EV P001

References

1. "TOYOTA Racing Finalises 2012 Driver Line-Up". Toyota. 10 February 2012. Retrieved 12 February 2012.
2. "Wurz among Toyota Le Mans line-up". Yahoo! Eurosport (TF1 Group). 8 January 2012. Retrieved 12 January 2012.
3. TS030 Hybrid Technical Information, http://www.toyotahybridracing.com/team/car/
4. "Toyota reveals TS030 Hybrid endurance". Autoblog Green (AOL). 25 January 2012. Retrieved 26 January 2012.
5. Watkins, Gary (24 January 2012). "Toyota expands Le Mans 24 Hours attack to two LMP1 cars". Autosport (Haymarket Publications). Retrieved 26 January 2012.
6. Raby, Mark (25 January 2012). "Toyota TS030 race cars revealed, prove hybrids aren’t boring". Slash Gear (R3 Media, LLC). Retrieved 26 January 2012.
7. Dube, Zerin. "ACO/FIA Announce Hybrid Braking Zones". Speed Sport Life. Retrieved 1 June 2012.
8. Pulman, Ben (25 January 2012). "Toyota TS030 Hybrid (2012) first pics of new Le Mans racer". Car Magazine (Neko Publishing). Retrieved 26 January 2012.
9. Elizalde, Pablo (11 April 2012). "Toyota forced to miss Six Hours of Spa after Paul Ricard testing crash". Autosport (Haymarket Publications). Retrieved 11 April 2012.
10. Antho (June 17, 2012). "Bitter-Sweet Le Mans Debut For TOYOTA Racing". Toyota Hybrid Racing News. Retrieved 10 September 2012.
11. "Toyota beats Audi to Brazil pole". Autosport.com (Haymarket Publications). 14 September 2012. Retrieved 15 September 2012.
12. Collins, Sam S. "Toyota TS030 (2013)". Race Car Engineering. Chelsea Magazines Ltd. Retrieved 18 May 2013.
13. TMG, Alastair. "EVENTFUL RACE FOR TOYOTA RACING AT SPA". Toyota Hybrid Racing. TMG. Retrieved 18 May 2013.
14. Watkins, Gary. "Toyota calls for Le Mans rules redress after Audi Spa performance". Autosport. Haymarket. Retrieved 18 May 2013.
15. Watkins, Gary. "Toyota and petrol LMP1s handed Le Mans 24 Hours performance break". Autosport. Haymarket. Retrieved 30 May 2013.