de Havilland Hornet

For the 1930s single-engine cabin biplane see: de Havilland Hornet Moth

D.H.103 Hornet
Sea Hornet
A de Havilland Hornet F.3 of 64 Squadron.
Role Land and naval-based fighter aircraft
National origin United Kingdom
Manufacturer de Havilland
First flight 19 April 1944
Introduction 1946
Retired 1956
Primary users Royal Air Force
Royal Navy
Produced 1945 to 1950
Number built 383


The de Havilland DH.103 Hornet was a twin-piston engined fighter aircraft that further exploited the wooden construction techniques pioneered by de Havilland's earlier Mosquito. Entering service at the end of the Second World War, the Hornet equipped postwar RAF Fighter Command day fighter units in the UK and was later used successfully as a strike fighter in Malaya. The Sea Hornet was a carrier-capable version.

Design and development

The Hornet prototype RR 915

Designed under a team led by R. E. Bishop with C. T. Wilkins assisting[1] as a private venture for a long-range fighter destined for the Pacific Theatre in the war against Japan, Specification F.12/43 was written around the type. From an early stage it was also envisaged that the Hornet could be adapted for naval use, operating from aircraft carriers. As a result, priority was given to ease of control, especially at low speeds, and good pilot visibility. Construction was of mixed balsa/plywood similar to the Mosquito, but the Hornet differed in incorporating stressed Alclad lower-wing skins bonded to the wooden upper wing structure using the then-new adhesive Redux.[2] The two wing spars were redesigned to withstand a higher load factor of 10 versus 8.[3]

Apart from the revised structure, the Hornet's wings were a synthesis of aerodynamic knowledge that had been gathered since the Mosquito's design process, being much thinner in cross-section, with de Havilland designers adopting a laminar flow profile similar to the P-51 Mustang and Hawker Tempest. The control surfaces consisted of hydraulically-operated split flaps extending from the wing root to outboard of the engine nacelles; as on the Mosquito, the rear of the nacelle was part of the flap structure. Outboard, the Alclad-covered ailerons extended close to the clipped wingtips and gave excellent roll control.[4]

The Hornet used "slimline" Rolls-Royce Merlin engines with engine ancillaries repositioned to minimise frontal area and drag. It was unusual for a British design in having propellers that rotated in opposite directions; the two engine crankshafts rotated in the same direction, but the Merlin 131 added an idler gear to reverse its propeller's rotation (to clockwise, viewed from the front).[3] This cancelled the torque effect of two propellers turning in the same direction that had affected earlier designs (such as the Mosquito). [N 1] It also reduced adverse yaw caused by aileron trim corrections and generally provided more stable and predictable behaviour in flight. De Havilland tried propellers that rotated outward at the tops of their arcs (as in the P-38 Lightning),[6] but this configuration blanketed the fin and reduced rudder effectiveness at low speeds, compromising ground handling; on production Hornets the conventionally rotating Merlin 130 was on the port wing with the Merlin 131 on the starboard.[7]

Because of the revised induction arrangements of the Merlin 130 series, the supercharger and carburettor air intakes could be placed in the leading edges of the wings, outboard of the nacelles. Other versions of the Merlin, which used "updraft" induction arrangements, required that the intakes be placed in a duct below the main engine cowling. The main radiators were also mounted in the inboard leading edges of the wings. Internal fuel, to a maximum capacity of 432 Imp gal (1,964 l) (F 3) was stored in four self-sealing wing tanks which were accessed through detachable panels forming part of the lower wing surfaces.[3]

To assist airflow over the wing, the engine nacelles were mounted low, which meant that the undercarriage legs were reasonably short and the pilot's field of view was improved. The single-legged undercarriage units were simpler and cleaner than those of the Mosquito, using the same de Havilland-developed, rubber-in-compression energy absorption system. The main wheels were also smaller and lighter.

To further aid the pilot's field of view the unpressurised cockpit was mounted well forward in the fuselage and was housed under an aft-sliding, perspex blister canopy. The three-panel windscreen was designed so that refraction through the panels meant that there were no obvious blind spots caused by the corner tie-rods; all three panels were bullet-proof laminated glass. An armour-plated bulkhead (hinged near the top to provide access to the back of the instrument panel and the rudder pedals), was part of the nose structure, with the pilot's back and head being protected by another armoured bulkhead built into the cockpit. Below and behind the cockpit floor was a bay housing the built-in armament of four short-barrelled 20 mm (.79 in) Hispano V cannon, with 190 rpg, firing through short blast tubes.

Fuselage construction was identical to the earlier Mosquito; a balsa wood "pith" sandwiched between plywood sheets which were laid in diagonal panels. Aerolite formaldehyde cement was the bonding agent.[8] The fuselage halves were built on large concrete or wood patterns, equipment was fitted in each half and they were then joined along the top and bottom centre lines using wooden reinforcing strips. The entire fuselage was then tightly wrapped in fine aviation fabric which was doped in place. The tailfin which had the trademark, gracefully curved de Havilland shape, was an integral part of the rear fuselage. On Late Mk Is and future production aircraft, a fin fillet was added to the base of the unit.

The horizontal tail unit was an all-metal structure, again featuring the distinctive de Havilland shape[3] later repeated on the Chipmunk and Beaver.

Hornet F 3

The Hornet F 3's wings were stressed to carry external ordnance. Two to four 60 lb (27 kg) RP-3 rockets could be carried under each wing; it was also possible to carry a combination of four rockets with one bomb of up to 1,000 lb (454 kg), or an additional drop tank on each wing, ranging in capacity up to 200 Imp gal (909 l). Internally, the fuel tanks were enlarged from a total capacity of 360 Imp gal (1,636 l) to 432 Imp gal (1,964 l) and additional equipment was added. Larger horizontal tail surfaces were adopted, with larger elevator horn balances. With the evolution of longer-range, jet-powered fighters such as the de Havilland Vampire, de Havilland Venom and Gloster Meteor, the Hornet became obsolete fairly quickly. The F 3 was the last Hornet derivative to see operational RAF service.[9]

Hornet PR 2 and FR 4

The Hornet PR 2 was intended to operate as a long-range Photo-reconnaissance aircraft. The Hispano cannon were removed and cameras were mounted in the rear fuselage. Total internal fuel capacity was increased to 528 gal (2,400 l). PX216, PX220 and PX249 converted from standard Mk Is, were the prototypes, followed by five more. The requirement for these aircraft lapsed with the end of the Second World War in the Pacific; all were used in arrester barrier trials at Boscombe Down, and scrapped before entering RAF service.

Twelve Hornet FR 4s were modified from F 3s in much the same way, except that the cannon were retained and the internal fuel capacity slightly reduced from that of the fighter. These FR 4 derivatives saw service with the RAF in Malaya and Hong Kong in the early 1950s.

Sea Hornet F 20, NF 21 and PR 22

Sea Hornet NF.21 of the Airwork FRU displayed at RNAS Stretton in 1955. The radar thimble nose of this variant is evident

The Hornet was designed with the possibility of naval service on carriers firmly in mind. To this end good low-speed handling was required, along with good allround visibility for the pilot. The basic Hornet design excelled at meeting these requirements.

Shortly after the first Hornet prototype flew, Specification N.5/44 was issued to de Havilland covering the modification of the Hornet for naval service. The Heston Aircraft Company was contracted to carry out the conversion work on three early production F.Is. The work entailed altering the wings to incorporate folding mechanisms so that each outer wing panel, from the aileron/flap line outboard could be folded upwards and inwards at an angle. The hinges were part of the upper wing skin structure while the lower wing skins incorporated securing latches. Lockheed hydraulic jacks were used to actuate the wing panels. Slotted flaps were introduced to improve low speed "flaps down" control.

The lower rear fuselage was reinforced with two additional spruce longerons designed to take the stresses imposed by the external "vee" framed arrestor hook, which was flush-mounted below the fuselage. The frame was made up of steel tubing with a forged-steel hook and was held against the fuselage by a "snap gear". Because the Hornet used the American "3-point" system of catapult-assisted takeoff, two forged steel catapult bridle hooks were fitted, one below each wing, close to the fuselage.[4]

The de Havilland rubber-in-compression undercarriage legs could not absorb the rebound energies imposed by carrier landings. They were replaced by more conventional hydraulic oleos which embodied torque links.[10] Merlin 133/134s (derated from 2,070 hp/1,543 kW to 2,030 hp/1,535 kW) were fitted to all Sea Hornets.

Other specialised naval equipment (mainly different radio gear), was fitted and provision was made for three camera ports, one on each side of the rear fuselage and one pointing down. Sea Hornet F 20s also incorporated the modifications of the Hornet F 3, although the internal fuel capacity was 347 Imp gal (1,557 l), slightly reduced from that of the F I. In total, all of the modifications added some 550 lb (249 kg) to the weight of the aircraft. Maximum speed was decreased by 11 mph (18 km/h).[3]

The Hornet NF 21 was designed to fill a need for a naval night fighter. Special flame-dampening exhausts were installed, and a second basic cockpit was added to the rear fuselage, just above the wing trailing edges. ASH radar equipment was placed in the rear of this cockpit, with the radar operator/navigator seated facing aft. To gain access, a small trapdoor was provided in the lower fuselage; a fixed, teardrop-shaped bubble canopy, which could be jettisoned in an emergency, provided a good field of view. At the front of the aircraft, the nose underwent a transformation with the small rotating ASH radar dish being housed under an elongated "thimble" radome. The horizontal tail units were increased in span. The effect of these modifications on performance was minimal; about 4 mph (6 km/h)

The Sea Hornet PR 22 was a dedicated photo reconnaissance aircraft version of the F 20. The cannon were removed and the apertures faired over. Three cameras were installed in the rear fuselage; two F 52s for nocturnal (night) use and one K.19B for diurnal (day). A total of 23 PR 22s were built, interspersed with F.20s being built at Hatfield.[11]

Civilian Hornet

The lone civilian Hornet was a Sea Hornet F 20 TT193. It had been sent to Edmonton, Alberta, Canada for winter trials and was later sold rather than be transported back to England. Registered CF-GUO, it was operated by Spartan Air Services and Field Aviation until 11 June 1952 when an engine failure caused a forced landing at Terrace, British Columbia. Some of the remains are still there in private hands.[12]

Flying the Sea Hornet

de Havilland Sea Hornet F Mk 20s of No 728 Fleet Requirements Unit, Hal Far, Malta.

Captain Eric "Winkle" Brown, former fighter pilot and officer of the Fleet Air Arm, was one of the world's most accomplished test pilots and he still holds the record for flying the greatest number of different aircraft types.

Just after VE Day the first semi-navalised Sea Hornet PX 212 arrived at the RAE, Farnborough. Eric Brown initiated "work-up to deck-landing" trials. 37 years later, he was still impressed:

"...the next two months of handling and deck landing assessment trials were to be an absolute joy; from the outset the Sea Hornet was a winner!"
"The view from the cockpit, positioned right forward in the nose beneath a one-piece aft-sliding canopy was truly magnificent. The Sea Hornet was easy to taxi, with powerful brakes... the takeoff using 25 lb (2,053 mm Hg, 51" Hg) boost and flaps at one-third extension was remarkable! The 2,070 hp (1,540 kW) Merlin 130/131 engines fitted to the prototypes were to be derated to 18 lb (1,691 Hg, 37" Hg) boost and 2,030 hp (1,510 kW) as Merlin 133/134s in production Sea Hornets, but takeoff performance was to remain fantastic. Climb with 18 lb boost exceeded 4,000 ft/min (1,200 m/min)"...
"In level flight the Sea Hornet's stability about all axes was just satisfactory, characteristic, of course, of a good day interceptor fighter. Its stalling characteristics were innocuous, with a fair amount of elevator buffeting and aileron twitching preceding the actual stall"...
"For aerobatics the Sea Hornet was absolute bliss. The excess of power was such that manoeuvres in the vertical plane can only be described as rocket-like. Even with one propeller feathered the Hornet could loop with the best single-engine fighter, and its aerodynamic cleanliness was such that I delighted in its demonstration by diving with both engines at full bore and feathering both propellers before pulling up into a loop!"[13][N 2]

During this series of tests Captain Brown found that the ailerons were too heavy and ineffectual for deck landing and there were some problems with throttle movement, brakes and the rubber-in-compression undercarriage legs were still fitted. De Havilland were quick to modify the aircraft. Eric Brown:

"Landings aboard Ocean had been made without any crash barrier... Yet, in the case of the Sea Hornet, I had felt such absolute confidence that I was mentally relaxed... Indeed, there was something about the Sea Hornet that made me feel that I had total mastery of it; I revelled in its sleek form and the immense surge of power always to hand..."
"Circumstances had conspired against the Sea Hornet in obtaining the recognition that it justly deserved as a truly outstanding warplane...in my book the Sea Hornet ranks second to none for harmony of control, performance characteristics and, perhaps most important, in inspiring confidence in its pilot. For sheer exhilarating flying enjoyment, no aircraft has ever made a deeper impression on me than did this outstanding filly from the de Havilland stable."[14]

Operational history

Hornet

The Hornet prototype RR 915 first flew on 28 July 1944 with Geoffrey de Havilland Jr. at the controls.[15] Powered by twin Merlin engines, it was the fastest twin piston-engined fighter in Royal Air Force service, a little slower than the fastest (single) piston-engined Supermarine Spiteful. The Hornet also has the distinction of being the second fastest wooden aircraft ever built, after the Heinkel He 162, and the second fastest operational twin propeller-driven aircraft — being slightly slower than the unconventional German Dornier Do 335 of 1945.

The prototype achieved 485 mph (780 km/h) in level flight, which came down to 472 mph (760 km/h) in production aircraft.

The Hornet entered service in 1946 with 64 Squadron based at RAF Horsham St Faith. Next to convert to the Hornet was 19 Squadron at RAF Wittering, followed by 41 Squadron and 65 Squadron, both based at RAF Church Fenton. No. 65 Sqn was to participate in one of the first official overseas visits by an RAF unit when they visited Sweden in May 1948. Pilot conversion to the Hornet was provided by No. 226 Operational Conversion Unit (O.C.U.) which was based at RAF Molesworth.[9][N 3]

During their relatively short operational service Hornets participated in several record attempts and air races; for example, on 15 September 1949 Flight Lieutenant H. Peebles flew from RAF Bovingdon to Gibraltar at an average speed of 357.565 mph (574.445 km/h), setting a new British point-to-point record, only to see it broken three days later when Group Captain A.P.C. Carver flew back to Bovingdon, averaging 435.871 mph (701.466 km/h).

Operationally, the Hornet I (later F 1) was to last only a short time before being superseded by the F 3 version. The first Hornet F 3 was PX 366 which flew at the Farnborough Air Show in June 1946.

New units to convert to this mark were 33 Squadron, 45 Squadron (based at RAF Tengah, Singapore where, in early 1952, the unit converted to the Hornet from the unreliable Bristol Brigand) and 80 Squadron. Along with 64 Sqn these squadrons operated in Malaysia where they replaced Beaufighters and Spitfires operating against Communist guerrillas during the Malayan Emergency. Armed with rockets and/or 1,000 lb (454 kg) bombs Hornets, with their long range and good endurance, were able to spend up to two hours loitering over the target area. They also proved to be very reliable; 45 Sqn Hornets, based in Singapore achieved 4,500 operational sorties over five years.[9] The last operational Hornet sortie was flown on 21 May 1955.[16]

On 23 July 1954, two Hornets from RAF Kai Tak in Hong Kong were the first to arrive on the scene of a shootdown of a Cathay Pacific Skymaster off the coast of Hainan Island.[17]

All Hornets were withdrawn from operational service by mid-1956.[18] No complete examples of the Hornet remain in existence today.

Sea Hornet

DH.103 Sea Hornet NF.21 displayed at RNAS Stretton in 1955 with wings folded. Also shown are the "handed" propellers of Hornets and Sea Hornets.

The Sea Hornet F 20 prototype, PX 212, which did not have the wing-fold mechanism, first flew on 19 April 1945. PX 212 was later converted to the prototype NF Mk 21, first flying in this form on 9 July 1946.

The only unit fully equipped with Sea Hornet F 20s was 801 Squadron on 1 June 1947 at RNAS Ford. After a move to Arbroath the squadron embarked on HMS Implacable. In 1951, another move was made to HMS Indomitable until, in June, the Sea Hornets were replaced by Hawker Sea Furies.[11]

Other Sea Hornets were attached to various Naval Squadrons, including three which were attached to 806 Squadron which, along with a Vampire and two Sea Furies, were embarked on HMCS Magnificent for a tour of North America in 1948. The Sea Hornets gave several spectacular flying displays at the International Air Exposition in New York between 31 July and 8 August.[11] In mid-1948, one Sea Hornet, PX219, was adapted to carry 2 × Highballs in an installation that was developed but not applied to the fleet. The equipment was removed during January 1949 and it is currently unknown if the Hornet ever dropped a Highball during flight.[19]

In January 1949, the Sea Hornet NF 21-equipped 809 Squadron at RNAS Culdrose, moved to HMS Illustrious and then, in May 1951, to HMS Vengeance. The unit was then briefly seconded to the RAF at Coltishall before a posting to Hal Far Malta where it disbanded in 1954. The NF.21 later equipped the Fleet Requirements Units at Hal Far, Malta, and St Davids, West Wales.

One Sea Hornet F 20, TT 213, was acquired by the RAAF from the Ministry of Supply in the United Kingdom. The aircraft was used by the Aircraft Research and Development Unit (ARDU), at Laverton, Victoria, Australia from 1948 to 1950. It was mainly used for evaluation and tropical trials.

As with its land-based cousin, no complete examples of the Sea Hornet remain extant.

Existing Remains

Preserved parts from a Hornet can be found in the UK and Canada. The UK-based project has a forward fuselage reconstruction for a Hornet F.I. This includes many original parts, with the new-build items being made to original drawings. The same collection has a sizable piece of wing, main and tailwheels, and two canopies. Two rear fuselage sections (VX250 and VW957) are also in store, as well as the belly door, a main undercarriage leg and one rear engine/undercarriage fairing. In the province of Alberta, Canada a fragmented wing section from TT193 is in store.

Variants

Hornet F 1
Fighter version, 60 built.
Hornet PR 2
Photo-reconnaissance version, five built.
Hornet F 3
Fighter version, 132 built.
Hornet FR 4
Fighter-reconnaissance version, 12 built.
Sea Hornet F 20
A navalised version for service on British aircraft carriers, 79 built.
Sea Hornet NF 21
Fleet Air Arm night fighter powered by Merlin 133/134 engines, 72 built.
Sea Hornet PR 22
Photo-reconnaissance version, 23 built.

Operators

 Australia
 Canada
 United Kingdom

Specifications (Hornet F.1)

Sea Hornet N.F.21 (with second cockpit for observer)

Data from [20][21][22]

General characteristics

Performance

Armament

Avionics
ASH radar fitted in Sea Hornet NF Mk 21.

See also

Related development
Aircraft of comparable role, configuration and era

References

Notes

  1. ↑ The Hornet was designed with "handed" engines and powerful flaps to cancel out any handling problems during takeoff or landing.[5]
  2. ↑ A photo of PX212, with Captain Brown at the controls and both propellers feathered is shown at the start of this page.[13]
  3. ↑ All these units had previously flown single engine fighters (19, 64 and 65 Sqns on Mustang Mark IIIs and IVs and 41 Sqn. on Spitfire XIVs).

Citations

  1. ↑ http://www.flightglobal.com/pdfarchive/view/1979/1979%20-%200464.html
  2. ↑ Moss 1946, p. 300.
  3. 1 2 3 4 5 Godfurnon, Nicholas. "The de Havilland 'Hornet' & 'Sea Hornet': Two-Engined Fighter of Composite Wood and Metal Construction." skynet.be. Retrieved: 4 October 2009.
  4. 1 2 Clark 1987, p. 479.
  5. ↑ Jackson 1987, p. 438.
  6. ↑ A photo in the Putnam on De Havilland shows the second prototype RR919 with two conventionally rotating Merlins.
  7. ↑ Clark 1987, p. 482.
  8. ↑ Buttler 2003, pp. 114–115.
  9. 1 2 3 Hall 1990
  10. ↑ Clark 1987, p. 483.
  11. 1 2 3 Buttler 2003, p. 125.
  12. 1 2 Milberry 1984, p. 73.
  13. 1 2 Brown 1982, p. 195.
  14. ↑ Brown 1982, p. 198.
  15. ↑ Bowman 1997, p. 52.
  16. ↑ "50th Anniversary." dehavillandmuseum. Retrieved: 4 October 2009.
  17. ↑ Harper, Jim. "VR-HEU - Life & Times of James Harper." helianthus-productions.com. Retrieved: 1 April 2010.
  18. ↑ Buttler 2003, pp. 124–125.
  19. ↑ Buttler et al. 2010, p. 48.
  20. ↑ http://www.wwiiaircraftperformance.org/Hornet/Hornet_I_aircraft_data_card.jpg
  21. ↑ http://www.wwiiaircraftperformance.org/Hornet/Hornet_I_range_table.jpg
  22. ↑ http://www.wwiiaircraftperformance.org/Hornet/Hornet_F1_weight.jpg

Bibliography

  • Birtles, Philip J. The De Havilland Hornet (Profile Publications No. 174). Leatherhead, Surrey, UK: Profile Publications Ltd., 1967.
  • Bowman, Martin W. "Sting of the Hornet." Air Classics, Vol. 33, No. 6, June 1997.
  • Bridgman, Leonard, ed. "The D.H. 103 Hornet" Jane’s Fighting Aircraft of World War II. London: Studio, 1946. ISBN 1-85170-493-0.
  • Brown, Eric (Captain, CBE DSC AFC RN). "Viewed from the Cockpit: Sea Hornet Supreme". Air International, Vol. 23, No. 4, October 1982, pp. 192–199.
  • Buttler, Tony. de Havilland Hornet and Sea Hornet (Warpaint Series no. 19). Newcastle, UK: Hall Park Books, 2000.
  • Buttler, Tony. "de Havilland Hornet & Sea Hornet." Aeroplane Monthly, Vol. 10, Autumn/Fall 2003.
  • Buttler, Tony. "Type Analysis: de Havilland Hornet and Sea Hornet." International Air Power Review Monthly, Vol. 33, No. 6, June 2005.
  • Buttler, Tony, David Collins and Martin Derry. Hornet and Sea Hornet. Stamford, UK: Dalrymple and Verdun Publishing, 2010. ISBN 978-1-905414-12-3.
  • Caruana, Richard. "The De Havilland Hornet" Scale Aviation Modeller International, October 2002, pp. 943–951.
  • Clark, J.H. "Forties Favorites 5 - de Havilland D.H 103". Aeroplane Monthly (Article first appeared in The Aeroplane, 25 January 1946), Vol. 15, No. 9, September 1987.
  • Cooper, Lewis G. The Hornet File. Tonbridge, Kent, UK: Air-Britain (Historians) Publications, 1992. ISBN 0-85130-202-5.
  • Hall, Alan W. "Aircraft In Detail: de Havilland DH.103 Hornet". Scale Aircraft Modelling, Vol. 12, No. 8, 8 May 1990.
  • Jackson, A.J. De Havilland Aircraft since 1909. London: Putnam, Third edition 1987. ISBN 0-85177-802-X.
  • Milberry, Larry. Sixty Years: The RCAF and Air Command 1924-1984. Toronto: Canav Books, 1984. ISBN 0-07-549484-1.
  • Mondey, David. British Aircraft of World War II (Hamlyn Concise Guide). London: Bounty Books, 1982. ISBN 0-7537-1462-0.
  • Moss, Charles J. "Aeronautical Engineering: Bonding with Redux." The Aeroplane No. 329, 20 September 1946.
  • White, Ian. "End of the Line: DH Hornet - last of the Fleet Air Arm's piston night-fighters." Air Enthusiast, no. 111, May/June 2004, pp. 50–55.
  • Wixey, Ken. "Ahhhh! Hornet!" FlyPast, No. 156, July 1994.

External links

Wikimedia Commons has media related to De Havilland DH.103 Hornet.
Wikimedia Commons has media related to De Havilland Sea Hornet.
This article is issued from Wikipedia - version of the Thursday, April 28, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.