Inertial Upper Stage

Inertial Upper Stage

Painting of Ulysses deploying from the Space Shuttle
Manufacturer Boeing
United Technologies
Country of origin United States
Used on Space Shuttle
Titan 34D
Titan IV
General characteristics
Height 5.2 m (17 ft)[1]
Diameter 2.8 m (9 ft 2 in)
Gross mass 14,700 kg (32,400 lb)
Associated stages
Derivatives TOS
Launch history
Status Retired
Total launches 24
Successes
(stage only)		 21
Failed 2
Lower stage
failed		 1
First flight 30 October 1982
Last flight 14 February 2004[2]
Stage 1
Length 3.15 m (10.3 ft)[3]
Diameter 2.34 m (7 ft 8 in)[3]
Gross mass 10,400 kg (22,900 lb)[3]
Propellant mass 9,700 kg (21,400 lb)[1]
Engines Orbus-21
Thrust 190 kN (43,000 lbf)[1]
Specific impulse 295.5 s[3]
Burn time up to 150 seconds[1]
Fuel Solid
Stage 2
Length 1.98 m (6 ft 6 in)[3]
Diameter 1.60 m (5 ft 3 in)[3]
Gross mass 3,000 kg (6,600 lb)
Propellant mass 2,700 kg (6,000 lb)[1]
Engines Orbus-6
Thrust 80 kN (18,000 lbf)[1]
Specific impulse 289.1 s[3]
Fuel Solid

The Inertial Upper Stage (IUS), originally designated the Interim Upper Stage, was a two-stage solid-fueled rocket upper stage developed by Boeing for the United States Air Force beginning in 1976[4] for raising payloads from low Earth orbit to higher orbits or interplanetary trajectories following launch aboard a Titan 34D or Titan IV rocket, or from the payload bay of the Space Shuttle.

Development

During the development of the Space Shuttle, NASA, with support from the Air Force, wanted an upper stage that could be used on the Shuttle to deliver payloads from low earth orbit to higher energy orbits such as GTO or to escape velocity for planetary probes. The candidates were the Centaur, propelled by liquid hydrogen and liquid oxygen, the Transtage, propelled by hypergolic storable propellants Aerozine-50 and N2O4, and the Interim Upper Stage, using solid propellant. The DOD reported that Transtage could support all defense needs, but could not meet NASA's scientific requirements, the IUS could support most defense needs and some science missions, while the Centaur could meet all needs of both the Air Force and NASA. Development began on both the Centaur and the IUS, and a second stage was added to the IUS design which could be used either as an apogee-kick motor for inserting payloads directly into geostationary orbit or to increase the payload mass brought to escape velocity.[5] Development of the Shuttle-Centaur was halted after the Challenger disaster, and the Interim Upper Stage became the Inertial Upper Stage.

When launched from the Space Shuttle, IUS could deliver up 2,270 kilograms (5,000 lb) directly to GEO or up to 4,940 kilograms (10,890 lb) to GTO.[3]

The first launch of the IUS was in 1982 on a Titan 34D rocket from the Cape Canaveral Air Force Station shortly before the STS-6 Space Shuttle mission.[6] Boeing was the primary contractor for the IUS[7] while Chemical Systems Division of United Technologies built the IUS solid rocket motors.[8]

Applications

The Galileo spacecraft and its attached Inertial Upper Stage (IUS) booster being deployed after being launched by the Space Shuttle Atlantis on the STS-34 mission

On Titan launches, the Titan booster would launch the IUS, carrying the payload into low Earth orbit where it was separated from the Titan and ignited its first stage, which carried it into an elliptical "transfer" orbit to a higher altitude. On Shuttle launches, the orbiter's payload bay was opened, the IUS and its payload raised to a 50° angle, and released. After the Shuttle separated from the payload to a safe distance, the IUS first stage ignited and, as on a Titan booster mission, entered a "transfer orbit". Upon reaching apogee, the first stage and interstage structure were jettisoned. The second stage then fired to circularize the orbit, after which it released the satellite and, using its attitude control jets, began a retrograde maneuver to enter a lower orbit to avoid any possibility of collision with its payload.

In addition to the Communication and Reconnaissance missions described above, which placed the payload into stationary (24-hour) orbit, the IUS was also used to boost spacecraft towards planetary trajectories. For these missions, the second IUS stage was separated and ignited immediately after first stage burnout. Igniting the second stage at low altitude (and thus, high orbital speed) provided the extra velocity the spacecraft needed to escape from Earth orbit (see Oberth effect). IUS could not impart as much velocity to its payload as Centaur would have been able to: while Centaur could have launched Galileo directly on a two-year trip to Jupiter, the IUS required a six-year voyage with multiple gravity assists.[9]

The final flight of the IUS occurred in February 2004.[2]

Flights

S/N[10] Launch Date Launch Vehicle Payload Remarks Image
2 1982-10-30 Titan 34D DSCS II F-16/III A-1 Mission successful despite telemetry loss for most of the flight.
1 1983-04-04 Space Shuttle
Challenger (STS-6)		 TDRS-1 (TDRS-A) Second stage tumbled due to a control system failure, resulting in an incorrect orbit. The spacecraft maneuvered itself into its final orbit.
11 1985-01-24 Space Shuttle
Discovery (STS-51-C)		 USA-8 (Magnum) Classified DoD payload
12 1985-10-03 Space Shuttle
Atlantis (STS-51-J)		 USA-11/12 (DSCS) Classified DoD payload
3 1986-01-28 Space Shuttle
Challenger (STS-51-L)		 TDRS-B Destroyed during launch[11]
7 1988-09-29 Space Shuttle
Discovery (STS-26)		 TDRS-3 (TDRS-C)
9 1989-03-13 Space Shuttle
Discovery (STS-29)		 TDRS-4 (TDRS-D)
18 1989-05-04 Space Shuttle
Atlantis (STS-30)		 Magellan Probe to Venus
8 1989-06-14 Titan IV (402) A USA-39 (DSP)
19 1989-10-18 Space Shuttle
Atlantis (STS-34)		 Galileo Probe to Jupiter
5 1989-11-23 Space Shuttle
Discovery (STS-33)		 USA-48 (Magnum) Classified DoD payload
17 1990-10-06 Space Shuttle
Discovery (STS-41)		 Ulysses Probe to the polar regions of the Sun
6 1990-11-13 Titan IV (402) A USA-65 (DSP)
15 1991-08-02 Space Shuttle
Atlantis (STS-43)		 TDRS-5 (TDRS-E)
14 1991-11-24 Space Shuttle
Atlantis (STS-44)		 USA-75 (DSP)
13 1993-01-13 Space Shuttle
Endeavour (STS-54)		 TDRS-6 (TDRS-F)
20 1994-12-22 Titan IV (402) A USA-107 (DSP)
26 1995-07-13 Space Shuttle
Discovery (STS-70)		 TDRS-7 (TDRS-G)
4 1997-02-23 Titan IV (402) B USA-130 (DSP)
21 1999-04-09 Titan IV (402) B USA-142 (DSP) IUS first and second stages failed to separate, payload placed into useless orbit
27 1999-07-23 Space Shuttle
Columbia (STS-93)		 Chandra X-ray Observatory
22 2000-05-08 Titan IV (402) B USA-149 (DSP)
16 2001-08-06 Titan IV (402) B USA-159 (DSP)
10 2004-02-14 Titan IV (402) B USA-176 (DSP)

Gallery

References

  1. 1 2 3 4 5 6 "Inertial Upper Stage". Retrieved July 2014.
  2. 1 2 "Inertial Upper Stage". Boeing. Archived from the original on 21 July 2012. Retrieved 21 July 2012.
  3. 1 2 3 4 5 6 7 8 "Inertial Upper Stage". Retrieved 21 July 2012.
  4. ↑ "Boeing launches two satellites". The Bulletin. UPI. 1 November 1982. p. 3. Retrieved 23 February 2014. Boeing won the contract to develop the IUS in 1976...
  5. ↑ Virginia Dawson; Mark Bowles. "Taming liquid hydrogen : the Centaur upper stage rocket" (PDF). nasa.gov. p. 172. Retrieved July 2014. They argued that the IUS, which was designed by the Air Force, was a potentially better rocket. The first stage of the two-stage rocket was capable of launching medium-sized payloads at most. This limitation would be overcome by means of the addition of a second stage for larger payloads with destinations into deeper space. Specifically, the Air Force asked NASA to develop an additional stage that could be used for planetary missions such as a proposed probe to Jupiter called Galileo.
  6. ↑ http://www.globalsecurity.org/space/library/report/1994/cape/cape2-6.htm
  7. ↑ http://www.globalsecurity.org/space/systems/t4-config-2b.htm
  8. ↑ http://science.ksc.nasa.gov/shuttle/technology/sts-newsref/carriers.html
  9. ↑ Virginia Dawson; Mark Bowles. "Taming liquid hydrogen : the Centaur upper stage rocket" (PDF). nasa.gov. p. 211. Retrieved July 2014.
  10. ↑ Krebs, Gunter. "IUS". Gunter's Space Page. Retrieved 21 July 2012.
  11. ↑ "Tracking and Data Relay Satellite System (TDRSS)". NASA Space Communications. Retrieved 2009-06-25.

External links

This article is issued from Wikipedia - version of the Sunday, August 30, 2015. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.