PKP class SP32

SP32
Type and origin
Power type Diesel-electric
Builder Romania FAUR
Build date 1985 – 1991
Total produced 150
Specifications
UIC class Bo-Bo
Gauge 1,435 mm (4 ft 8 1⁄2 in)
Bogies 2
Wheel diameter 1,100 mm (43 in)
Length 16,000 mm (52 ft 6 in)
Width 3,100 mm (10 ft 2 in)
Height 4,220 mm (13 ft 10 in)
Adhesive weight 181,42 kN
Loco weight 74 t
Fuel type Diesel
Fuel capacity 3,000 l (660 imp gal; 790 US gal)
Prime mover M820SR
12V396TC12
12V396TC14
Engine type four-stroke
Traction motors MCT 542
Transmission electrical
Loco brake Oerlikon
Performance figures
Maximum speed 100 km/h (62 mph)
Tractive effort 957 hp
1015 hp
Career
Operators PKP
Class Poland SP32
Number in class 150
Nicknames Odkurzacz
Delivered 1985

SP32 is a Romanian series of diesel passenger locomotives used by PKP.[1]

History

The start of the 1980s was the dawn of Polish steam locomotives era. New diesel locomotives were needed for pulling passenger trains.[2] Locomotives that were able to heat carriages with electrical systems were most in demand.[1] Due to an economic crisis within Poland, it was impossible to start local production, so PKP decided to buy 200 locomotives produced in FAUR (former 23 August Works) from Bucharest, Romania.[1] This company had previously produced Lxd2 and MBxd2 narrow gauge locomotives for PKP.[3]

First two locomotives began to work for PKP in 1985 and received the SP49 designation. Different series numbers were given as those locomotives were supposed to work in multiple steering. As other engines lacked that device, all locomotives were renamed to SP32-001 and 002.[4] Units were appointed to the Jasło, Nysa, Siedlce, and Zamość depots. The very first month of service revealed a series of failures that were reported back to the producer. Changes introduced afterwards did not limit the breakdowns. The most serious problems included failures of the diesel engines, compressors, and alternators. Additionally, their power proved to be insufficient, especially during winter when heating the carriages.[1]

These problems caused an end of their importation in 1991, after a total of 150 units. The last two locomotives (151 and 152) exchanged prototypes and their numbers were changed to 001 and 002. As the whole series had been far too young to be withdrawn, several attempts to upgrade the units were started. New diesel engines (12V396TC12 licensed by MTU) had the same power as previous ones, but were more reliable. They were installed in the following units: 073, 096, 147, 148, and 149.

In 2000, a more complex modernization of the SP32 series began. Locomotives were given new 12V396TC14 diesel engines with an electronic regulator produced by MTU, on-board diagnostics system, more convenient dashboards, fire extinguishing installation, and new lights. The leasing company that now owns and lends PKP modernized locomotives funded the modernization. Units with all those improvements were numbered from 201 to 210. Presently, only those locomotives are in use, with the rest remaining as reserve. About one-third of the locomotives have been scrapped.[3]

Technical data

SP32 is a Bo-Bo locomotive as it runs on two bogies, each equipped with two axles. Each axle is propelled separately by one traction motor. Power from diesel engine to traction motors is delivered through electrical transmission. The electric heating system is powered by a 250 kW alternator that allows the locomotive to heat six carriages (assuming 40 kW power consumption per carriage). During summer months all power from heating is transferred to traction motors, thus increasing tractive effort.[1] Traction motors, bogies, transmissions, and compressor, as well as several different parts are similar to those used in ST43 locomotive.

SP32 has a non-typical for Polish passenger locomotives box construction. It has only one crew compartment, located approximately two-thirds of way down the locomotive. Thanks to a replaceable dashboard, driving in both directions is comfortable. The relatively low weight this locomotive puts on rails allows it to run on tracks laid on unstable surfaces.[3]

Nicknames

References

  1. 1 2 3 4 5 Jarek D. Stwarz (1997–2002). "Chester Home Page". Archived from the original on September 2, 2007. Retrieved October 21, 2007.
  2. ↑ "Regionalny Portal Kolejowy". 2006–2007. Retrieved October 21, 2007.
  3. 1 2 3 Przemysław Gołembiecki, Tomasz Gacki (2003). "Serwis Kolejowy". Archived from the original on January 5, 2008. Retrieved October 21, 2007.
  4. ↑ "Lokomotywa pasażerska serii SP49". Retrieved October 21, 2007.
  5. ↑ Wojciech Cupiał. "Kolejowa strona MZK z Podkarpacia". Archived from the original on September 11, 2007. Retrieved October 21, 2007.

External links

Wikimedia Commons has media related to PKP class SP32.
This article is issued from Wikipedia - version of the Sunday, February 14, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.