Saturn I SA-4

Mission type

Test flight

Operator

NASA

Mission duration

15 minutes

Distance travelled

400 kilometers (250 mi)

Apogee

129 kilometers (80 mi)

Spacecraft properties

Launch mass

52,480 kilograms (115,700 lb)

Start of mission

Launch date

March 28, 1963, 20:11:55 UTC

Rocket

Saturn I

Launch site

Cape Canaveral LC-34

End of mission

Decay date

March 28, 1963, 20:26:55 UTC

Project Apollo Unmanned tests
← Saturn I SA-3	Saturn I SA-5 →

SA-4 was the fourth launch of a Saturn I launch vehicle and the last of the initial test phase of the first stage. It was part of the Apollo Program.

Objectives

SA-4 was the last flight to test only the S-I first stage of the Saturn I rocket. As with the first three launches this would be a suborbital flight and would test the structural integrity of the rocket.

The major addition to this flight was that, in order to test the rocket's ability to deal with an engine failure during the flight, one of the engines would be programmed to shut down about 100 seconds after launch. If all went well the rocket would reroute the fuel for this engine to the other engines and have the rocket burn longer to compensate for the loss of acceleration. This was used successfully on the later Apollo 6 and Apollo 13 flights.

Also on this flight, the dummy second stage was outfitted with the aerodynamic design of the real second stage. This included vent ducts, fairings and dummy camera pods. The rocket also flew with antennae designed for the Block II version of the rocket.

Flight

SA-4 on Pad 34

After the shortest checkout time of any rocket at 54 days, SA-4 went on to experience the longest series of holds of any mission at 120 minutes. The SA-4 launch would be the final single-stage flight.

The rocket operated perfectly through the first 100 seconds of the flight, when the No. 5 engine shut off as planned. The rocket then continued to operate properly, the propellant system rerouting the fuel to the other engines. The No. 5 engine did not disintegrate because of heat caused by the lack of cooling propellant as some had predicted. This was an important test proving an important feature of the clustered engine design.

The rocket reached a maximum height of 129 km and a peak velocity of 5906 km per hour. At this stage it also fired retrorockets that would be used on later missions to separate the rocket stages. On SA-4 the stages were not designed to separate but tested the retrorockets to make sure they would fire.

External links

Wikimedia Commons has media related to Saturn-Apollo 4.

This article incorporates public domain material from websites or documents of the National Aeronautics and Space Administration.

Missions of the Apollo program

Rocket tests	SA-1 SA-2 SA-3 SA-4 SA-5 AS-203

Abort tests	QTV Pad Abort Test-1 A-001 A-002 A-003 Pad Abort Test-2 A-004

Boilerplate tests	AS-101 AS-102 AS-103 AS-104 AS-105

Unmanned missions	AS-201 AS-202 Apollo 4 Apollo 5 Apollo 6 Skylab 1

Low Earth orbit missions	Apollo 7 Apollo 9 Skylab 2 Skylab 3 Skylab 4 Apollo–Soyuz Test Project

Lunar orbit missions	Apollo 8 Apollo 10

Lunar landing missions	Apollo 11 Apollo 12 Apollo 14 Apollo 15 Apollo 16 Apollo 17

Failed missions	Apollo 1 (AS-204) Apollo 13

List of missions Mission types Kennedy Space Center Launch Complex 39 Canceled missions

This article is issued from Wikipedia - version of the Tuesday, February 16, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.