New South Wales 41 class locomotive

New South Wales 41 class

4105 heading for Campbelltown in March 1961

Type and origin Power type Diesel-electric Builder British Thomson-Houston, Rugby, United Kingdom Build date 1953/54 Total produced 10

Specifications UIC class Bo-Bo Gauge 4 ft 8 ^1⁄2 in (1,435 mm) Wheel diameter 42 in (1,067 mm) Length Over headstocks: 43 ft 0 in (13.11 m), Over coupler pulling faces: 47 ft 3 in (14.40 m) Width 9 ft 4 in (2.84 m) Height 14 ft 0 in (4.27 m) Axle load 20 long tons 10 cwt (45,900 lb or 20.8 t) Loco weight 82 long tons 0 cwt (183,700 lb or 83.3 t) Fuel type Diesel Fuel capacity 500 imp gal (2,300 L; 600 US gal) Lubricant cap 45 imp gal (200 L; 54 US gal) per engine Coolant cap 40 imp gal (180 L; 48 US gal) per engine Sandbox cap 11.5 cu ft (0.33 m^3) Prime mover Paxman 12-RPHL, 2 of RPM range 680-1300 Engine type Four-stroke diesel Aspiration Normally aspirated Generator British Thomson-Houston RTB 10844 Traction motors British Thomson-Houston 157AZ, 4 of Cylinders V12 Cylinder size 7 in × 7.75 in (178 mm × 197 mm)

Performance figures Maximum speed 57 mph (92 km/h) Power output Gross: 400 hp (298 kW) per engine, For traction: 360 hp (268 kW) per engine Tractive effort Continuous: 22,800 lbf (101.42 kN) at 11 mph (18 km/h)

Career Operators New South Wales Government Railways Number in class 10 Numbers 4101-4110 First run 30 October 1953 Withdrawn 30 June 1975 Preserved 4102 Disposition 1 preserved, 9 scrapped

The 41 class were a class of diesel locomotives built by British Thomson-Houston in the United Kingdom for the New South Wales Government Railways in 1953/54.

History

4108 brings a coal train from Narellan into Campbelltown

4102 at the New South Wales Rail Transport Museum, Thirlmere in 2001

4102 in storage at Broadmeadow Locomotive Depot in December 2012

In 1950 the New South Wales Government Railways ordered 10 diesel locomotives from Australian General Electric.^[1] The construction was sublet to British Thomson-Houston of Rugby in the United Kingdom with the body built by Metro Cammell, Birmingham.^[2][3] The first entered service in December 1953 and the last in February 1955.^[4] All were delivered painted in verdant green, in the 1960s all were repainted Indian red.

From their earliest days the locomotives suffered failures including overheating and fires. To try and overcome this the radiators were relocated further to the ends of all ten of the locomotives and air ducting was modified. In addition, two had their mufflers relocated. The modification was considered a success, but not rolled out across the rest of the class. The locomotives were equipped to operate in multiple however the cooling system layout saw radiator heat passing from the leading locomotive to the trailing one, resulting in the equipment being removed.^[1]

By the early 1960s with the twin Paxman 12-RPHL engines coming to the end of their useful life, the Mechanical Branch began looking at repowering options. With the cost of repowering and overhauling the Class 41s being two-thirds that of a new Class 48 and repair costs per mile over nine times greater, it was decided not to proceed with this.^[1]

One was set aside in December 1957 following two electrical fires, the second in April 1961, the third in September 1969, while overhauls ceased for the rest of the class in 1972 with each locomotive withdrawn as it suffered a major failure, the final locomotive being withdrawn in June 1975.^[1] The class were mainly confined to metropolitan Sydney operating local trip workings and shunting at Enfield yard.^[1]

Preservation

In December 1976, 4102 was placed by the Public Transport Commission in the custody of the New South Wales Rail Transport Museum and is now a designated NSW heritage item.^[5][6]

After it arrived at Thirlmere in January 1977, the seized engine that led to its demise was temporarily repaired by members of the Illawarra Group. In 1982 an engine failed whilst returning from a trip to Picton and as a consequence 4102 was then used as an one-engine shunter until the batteries finally wore out in 1987.

By July 1991 it had moved to CountryLink's XPT Service Centre in Sydenham (where the Paxman engined XPTs are maintained), where a spare engine was installed.^[7] It returned to Thirlmere in November 1992, but was not restored to service.^[8] In April 2009 4102 was moved for further storage at the Broadmeadow Locomotive Depot.

One of the Paxman diesel engines of 4102 as stored at Broadmeadow Locomotive Depot

Status table

Number	Serial No	Entered Service	Last Used	Withdrawn	Condemned	Scrapped	Kilometres Travelled
4101	1001	1 Dec 1953	6 Jun 1973	27 Jun 1973	2 Sep 1974	11 Jun 1975	463,514
4102	1002	30 Oct 1953	30 Jun 1975	19 Jul 1975	1 Dec 1975	Preserved THNSW	492,650
4103	1003	18 Jan 1954	2 Apr 1974	16 May 1974	2 Sep 1974	1 Sep 1975	462,871
4104	1004	13 Jan 1954	12 Oct 1973	26 Mar 1974	2 Sep 1974	29 Aug 1975	440,810
4105	1005	8 Feb 1954	31 Mar 1961	01 Apr 1961	May 1973	5 Oct 1972	149,281
4106	1006	21 Jan 1954	02 Jan 1958	05 Jan 1958	May 1973	27 Apr 1973	106,909
4107	1007	25 Jan 1954	11 Aug 1973	26 Mar 1974	2 Sep 1974	29 Aug 1975	446,167
4108	1008	22 Feb 1954	10 Sep 1969	10 Sep 1969	May 1973	20 Oct 1972	402,026
4109	1009	11 Mar 1954	9 Feb 1972	27 Jun 1973	2 Sep 1974	4 Jun 1975	426,074
4110	1010	10 Feb 1955	20 May 1974	25 May 1974	2 Sep 1974	1 Sep 1975	476,489

References

1. Leaver, Allan (January 1984). "41 Class Album". Roundhouse (NSW Rail Transport Museum).
2. "The 41-Class Diesel-Electric Locomotive". Australian Railway Historical Society Bulletin. January 1954. pp. 1–3.
3. 41 Class Railpage
4. Class 41 Vicsig
5. RailCorp S170 Heritage & Conservation Register RailCorp
6. Locomotive, Diesel 4102 NSW Government Environment & Heritage
7. "4102" Railway Digest August 1991 page 282
8. "Locomotives and Traffic 4102" Railway Digest March 1993 page 108

Further reading

• New South Wales Rail System Locomotives. Sydney: Archives Section, State Rail Authority of New South Wales. 1984.

External links

Media related to New South Wales 41 class locomotive at Wikimedia Commons