British Rail Class 41 (Warship Class)

This article is about the Warship Class locomotives. For the prototype High Speed Train power cars built in 1972, see British Rail Class 41 (HST).
British Rail Class 41

D600 'Active' at Reading in 1959
Type and origin
Power type Diesel-hydraulic
Builder North British Locomotive Co.
Serial number 27660–27664
Build date 1958–1959
Total produced 5
Specifications
Configuration A1A-A1A
UIC class (A1A)'(A1A)'
Gauge 4 ft 8 1⁄2 in (1,435 mm) standard gauge
Wheel diameter Driving: 3 ft 7 in (1.092 m)
Idling: 3 ft 3 1⁄2 in (1.003 m)
Wheelbase 50 ft 0 in (15.24 m)
Length 65 ft 0 in (19.81 m)
Width 8 ft 8 in (2.64 m)
Height 12 ft 10 in (3.91 m)
Loco weight 117 long tons (119 t; 131 short tons)
Fuel capacity 800 imp gal (3,600 l; 960 US gal)
Prime mover NBL-MAN L12V 18/21S, 2 off
Engine type V12 Diesel
Transmission Hydraulic, Voith L306r
MU working ■ Orange Square
Train heating Steam
Train brakes Vacuum
Performance figures
Maximum speed 90 mph (145 km/h)
Power output Engines: 1,000 bhp (746 kW) × 2
Tractive effort Maximum: 50,000 lbf (222 kN)
Continuous: 39,600 lbf (176 kN)
Loco brakeforce 88 long tons-force (877 kN)
Career
Operators British Railways
Numbers D600–D604
Nicknames "Warships”
Axle load class Route availability
Retired December 1967
Disposition All scrapped

The British Railways Class 41 diesel-hydraulic locomotives were built by the North British Locomotive Company in Glasgow during 1957 and 1958. Although they were withdrawn before TOPS was introduced, British Rail classified them as Class 41.[1] All were named after Royal Navy vessels, hence the nameplates each bore a subtitle "Warship Class".

History

The fleet was ordered by the British Transport Commission as direct comparison with British Rail Class 40, and were not actually wanted by the Western Region, who preferred their production fleet of D800 Warships. The D600s were the result of power politics within the BTC and the WR: the former was unwilling to sanction radical, stressed-skin lightweight construction locomotives at the time, while the latter was equally insistent that at least some of the new Type 4 power range locomotives on order be equipped with hydraulic transmission. They were much heavier than production Warships (almost 120 long tons (122 t; 134 short tons) compared to 80 long tons (81.3 t; 89.6 short tons)) and can be regarded as standard 1950s British design diesel locomotives that just happened to contain two lightweight, high-revving diesel engines coupled to hydraulic transmissions rather than one large, slow-revving diesel engine and electrical generator set. For this reason they were practically obsolete in design terms before they had left the drawing board.

Mechanical details

Each locomotive was equipped with two MAN L12V18/21A diesel engines, each set to produce 1000 hp (750 kW) at 1445 rpm. This conservative rating was partly because NBL was very inexperienced at constructing diesel locomotives and partly because the Voith L306r three speed transmissions available at the time were not able to accept more. MAN had refined the engine design to produce 1,100 hp (820 kW) at around the time the D600 order was placed with NBL. The A1A-A1A wheel arrangement likewise came about because the BTC-mandated heavyweight construction required 6 axles to keep to a 20-ton axle loading, but NBL could not work out how to create a pivotless bogie and driving arrangement for C-C wheel arrangement. There were no C-C diesel-hydraulic locomotives to use as a template in mid-1955. The arrangement produced a continuous tractive effort of 39,600 lbf (176 kN) at 12.6 mph (20.3 km/h). Unusually for a British diesel locomotive, the D600s had spoked wheels. They could work in multiple with each other or up to two D6300 locomotives using the orange square coupling code.

Service and liveries

The nameplate of D601 Ark Royal on display at the National Railway Museum. These were generally coloured red, but this was changed to black if the locomotive was repainted blue.

D600 was officially completed on 25 November 1957 but was not handed over to BR until that December. Some trial runs with passenger coaches were done in south-west Scotland before D600 was allocated to Swindon in January 1958. A press run was arranged for 17 February 1958 when D600 hauled a 340-ton train between London Paddington and Bristol Temple Meads with stops at Reading, Didcot and Swindon. The twin engine reliability came in handy when one of the engines cut out soon after leaving Bristol on the return run; the last 100 miles (160 km) back to London were on one engine only.

D601 appeared in March 1958 and was also initially allocated to Swindon. By June 1958, both were based at Plymouth Laira and D602-D604 were then allocated there from new.

Entering service between January 1958 and January 1959, the class initially worked on the London-Plymouth-Penzance route of the Western Region. On 16 June 1958 D601 hauled the Cornish Riviera Express non-stop from Paddington to Plymouth—the first diesel locomotive to do so. The maximum permitted loads for a D600 on such a run were 375 tons (381 tonnes) westbound (climbing the 1-in-37 of Dainton Bank, west of Newton Abbot, and up Hemerdon Bank's 1-in-42 in the opposite direction). The D600s continued on the fast Bristol/West of England trains until a dozen D800 Warships had been accepted into service. Later they were largely restricted to the line west of Plymouth, finally being withdrawn en bloc in December 1967. They were noted for being capable of over 90 mph (140 km/h) if worked well and did run at 100 mph (160 km/h) during their very early careers. D603 was damaged in an accident and was returned to NBL for repair in 1960: the cast light alloy cabs were replaced with sheet steel as the original NBL subcontractor for these items was not prepared to fabricate a small, one-off order. Swindon had a spare cab which wasn't used and survived long after the locos had been withdrawn before finally being sold for scrap.

From new the D600s wore standard BR green with a 4-inch (102 mm) light grey horizontal band between the cabs a few inches above the solebar.[2] By the time of withdrawal D600 was in all-over rail blue with full yellow ends,[2] D602 was blue with small yellow warning panels on each nose[2] and D601/3/4 were still green, albeit with yellow warning panels.

Withdrawal and scrapping

All five locomotives were withdrawn on 30 December 1967. By this time they were non-standard, even for hydraulic designs, although according to Laira staff reliability was not a problem as many have thought. BR had been ordered to reduce the number of main line locomotive classes from 28 to 15 by 1974, primarily by eliminating types which were known to be unreliable, had high maintenance costs or were so few in number as to be non-standard. As the table below shows, there was a substantial gap between delivery of D601 and D602 because NBL had to equip itself to construct the engines and transmissions for these three locomotives. By this time the first Swindon-built D800s had entered service and these were the lightweight and more powerful diesel-hydraulic locomotives that the WR really wanted.

D600 and D601 were sold to Woodham's Scrapyard in Barry. D600 was broken up within a couple of years but D601 remained intact until 1980. Preservation for D601 was denied on the ground that it was too far gone to be restored to operational condition and was not considered to be worth preserving for display only. The last survivor of what had been Class D600 was broken up without mourning in Woodhams Scrapyard, surrounded by locos which it had been intended to replace. D602-D604 were sold to Cashmore's of Newport who broke them up far more quickly than Woodhams (who concentrated on easily processible wagons before tackling locomotives). Somewhat ironically, as the fleet only lasted eight years in revenue-earning service, D601 actually spent more time in the scrapyard than it did hauling trains on the main line.

No Class D600 Warships survive in preservation, or indeed any main line North British diesel or electric products save for Class 84 25kV AC electric locomotive no. 84001.

Class details

Number Name Date to traffic Date withdrawn Cut up Notes
D600 Active 24 January 1958 30 December 1967 March 1970 at Woodhams, Barry[3] Date of order 16 November 1955
Maker's order no. L76.
D601 Ark Royal 28 March 1958 30 December 1967 July 1980 at Woodhams, Barry[3]
D602 Bulldog 3 November 1958 30 December 1967 November 1968 at Cashmore's, Newport[2]
D603 Conquest 21 November 1958 30 December 1967 November 1968 at Cashmore's, Newport[2]
D604 Cossack 20 January 1959 30 December 1967 September 1968 at Cashmore's, Newport[2]

Modelling

A 00 gauge kit has been available from Silver Fox models and this was also available as a ready to run model, made to order. Since Dapol have announced that a limited edition OO RTR model of the Class D600 will be produced in collaboration with Kernow Model Rail Centre[4] the Silver Fox model has been withdrawn. This is now expected to be available in late 2013.

Worsley Works produce a body kit in 'N', 2mm & 3mm scales. It's N Gauge produce the locomotives RTR in N scale.

References

  1. ↑ Marsden, Colin J. (2011). Diesel and Electric Locomotive Recognition Guide. Ian Allan. ISBN 978-0-7110-3637-6.
  2. 1 2 3 4 5 6 "Hydraulic Pioneers – The NBL "Warships"". Rail Blue. Retrieved 13 January 2009.
  3. 1 2 "Woodhams Scrapyard, Barry, South Wales.". Rail Blue. Retrieved 13 January 2009.
  4. ↑ Warship Limited Editions

Further reading

External links

Wikimedia Commons has media related to British Rail Class 41 (Warship Class).
This article is issued from Wikipedia - version of the Sunday, March 20, 2016. The text is available under the Creative Commons Attribution/Share Alike but additional terms may apply for the media files.